A SERVICE OF

logo

Open as PDF
next previous
Page26
7014-179D
December 16, 2011
R
CB 1200 Pellet Stove
9
Troubleshooting
Withproperinstallation,operation,andmaintenanceyourappliancewillprovideyears
oftrouble-freeservice.Ifyoudoexperienceaproblem,thistroubleshootingguide
willassistaqualiedservicepersoninthediagnosisofaproblemandthecorrective
actiontobetaken.This troubleshooting guide can only be used by a qualied
service technician.
Symptom
Possible Cause Corrective Action
Pluginappliance-No
response.
Nocurrenttooutlet.
7ampfusedefective.
#3snapdisctrippedordefective.
Controlboxdefective.
Checkcircuitbreakeratservicepanel.
Replacefuse.
Resetorreplacesnapdisc.
Replacecontrolbox.
Calllighton.Nore.
Nofuelinrepot.
Outoffuel.
#2snapdiscmaybedefective.
Vacuumswitchnotclosing,novacuum.
Controlboxdefective.
Checkhopper.Fillwithfuel.
Replacesnapdisc.
Checkexhaustblowerispluggedinand
operating.
Checkvacuumswitchispluggedin.
Checkvacuumhoseisingoodcondition,
clearandconnectedatbothends.
Checkthermocoupleisingoodcondition
andpluggedinproperly.
Makesureventingsystemisclean.
Makesurefrontdoorisclosed.
Replacecontrolbox.
Calllighton.Nore.
Partiallyburnedfuelin
repot.
Firepotclean-outplatenotclosed.
Firepotisdirty(missedignition).
Checkthatrepotclean-outplateisfully
closed.
Cleanrepot.Makesurethereisnoclinker
intherepot.
Clinkersmayhavetobebrokenupwith
repotscrapertoolorothermeans.
Calllighton.Nore.
Unburnedpelletsin
repot.
Firepotclean-outplatenotclosed.
Firepotisdirty.
Ignitionholeblocked.
Igniternotworking.
Controlboxdefective.
Checkthatrepotclean-outplateisfully
closed.
Cleanrepot.Makesurethereisnota
clinkerintherepot.Clinkersmayhaveto
bepushedoutofrepotwithrepotscraper
toolorothermeans.
Scrapewithsolidpieceofwire.
Removeashdrawertoseeifigniteris
glowingredonstart-up.
Checkigniterwiresforgoodconnection.
Replaceigniterusing1/4inchmale/female
spadeconnectors.
Replacecontrolbox.
Sloworsmokystart-up. Firepotclean-outplatenotclosed.
Firepotisdirty.
Excessiveamountoffuelatstart-up.
Checkthatrepotclean-outisfullyclosed.
Cleanrepot.Makesurethereisnota
clinkerintherepot.Clinkersmayhaveto
pushedoutofrepotwithrepotscraper
toolorothermeans.
Reducefeedrateusingfeedrateadjust-
mentcontrolrodlocatedinsidehopper.