A SERVICE OF

logo

Open as PDF
next previous
R
December 16, 2011
7014-179D
Page3
CB 1200 Pellet Stove
Section 1: Listing and Code Approvals
A. ApplianceCertications......................4
B. MobileHomeApproved......................4
C. GlassSpecications............................4
D. ElectricalRating..................................4
E. BTU&EfciencySpecications..........4
Section 2: Getting Started
A. Design,Installation&Location
 Considerations....................................5
B. LocatingYourAppliance&Chinmey.. 6
C. ThermostatLocation...........................6
D. Draft....................................................6
E. NegativePressure..............................6
F. FireSafety..........................................7
G. Tools&SuppliesNeeded...................7
H. InspectAppliance&Components.......7
Section 3: Dimensions & Clearances
A. ApplianceDimensions........................8
B. ClearancestoCombustibles...............9
C. HearthRequirements..........................10
Section 4: Vent Information
A. Chimney&ExhaustConnection.........11
B. VentingTerminationRequirements....11
C. EquivalentFeetofPipe.......................12
D. PipeSelectionChart............................12
Section 5: Venting Systems
A. Alcove.................................................13
B. ThroughtheWall.................................14
C. Vertical................................................15
D. ThroughtheWall&Vertical-Exterior. 15
E. Vertial-Internal...................................16
E. Masonry..............................................16
F. AlternateMasonry...............................16
Section 6: Mobile Home..................................17
Section 7: Appliance Set-Up
A. OutsideAirKit,Rear&Floor..............18
B. TopVentAdapter...............................19
C.
RearVent&ReartoTopVentAdapter
. 19
D. BrickSet.............................................20
E. BrickClip............................................20
F. LogSetPlacement..............................21
G. GrilleAssembly...................................21
H. LogoInstallation..................................21
I. DoorInstallation..................................22
J. ThermostatInstallation........................22
Section 8: Operating Instructions
A. FuelSize&Material............................23
B. GeneralOperationInformation...........23
C. BeforeYourFirstFire.........................24
D. StartingYourFirstFire........................24
E. FireCharacteristics.............................24
F. FeedRateAdjustment.......................24
G. IgnitionCycles....................................25
H. FrequentlyAskedQuestions...............25
Section 9: Troubleshooting............................26-28
Section 10: Maintaining & Servicing Appliance
A. ProperShutdownProcedures.............29
B. QuickReferenceMaintenanceChart. . 29
C. GeneralMaintenance&Cleaning.......29-32
D. HighAshFuelContentMaintenance..33
E. BlowerReplacement...........................33-34
F. BafeRemoval....................................34
G. IgniterReplacement............................34
 H. GlassReplacement.............................35

Section 11: Reference Material
A. ComponentFunctions&Locations.....36-37
B. ComponentLocations(Drawings)......38
C. ExplodedDrawings.............................39-40
D. ServiceParts&Accessories...............41-45
E. WarrantyPolicy...................................46-47
F. ContactInformation.............................48
TABLE OF CONTENTS
Safety Alert Key:
• DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury.
• WARNING!Indicatesahazardoussituationwhich,ifnotavoidedcouldresultindeathorseriousinjury.
• CAUTION! Indicatesahazardoussituationwhich,ifnotavoided,couldresultinminorormoderateinjury.
• NOTICE:Indicatespracticeswhichmaycausedamagetothereplaceortoproperty.