A SERVICE OF

logo

Open as PDF
next previous
Page28
7014-179D
December 16, 2011
R
CB 1200 Pellet Stove
Symptoms Possible Cause Corrective Action
Convectionblowerfailsto
start.
#1snapdiscdefective.
Blowernotpluggedin.
Blowerisdefective.
Controlboxisdefective.
Replacesnapdisc.
Checkthatblowerispluggedintowirehar-
ness.
Replaceblower.
Replacecontrolbox.
Exhaustblowerfailsto
startordoesnotshutoff.
Blowernotpluggedin.
Bloweriscloggedwithash.
Blowerisdefective.
Controlboxisdefective.
Checkthatblowerispluggedintowirehar-
ness.
Cleanexhaustsystem.
Replaceblower.
Replacecontrolbox.
Large,lazyame,orange
color.Blackashonglass.
Dirtyappliance.
Poorfuelquality,highashcontent.
Firepotclean-outplatenotcompletely
closed.
Excessiveamountoffuel.
Cleanunit,includingrepot,heatexchang-
ersandventingsystem.Removestainless
steelbafefromreboxtocleanashfrom
ontopofbafe.Cleanbehindrearbrick
panels.Changefuelbrandtopremium.
Checkthatrepotclean-outplateisfully
closed.
Reducefeedrateusingfeedrateadjustment
controlrodlocatedinsidehopper.
Nuisanceshutdowns. Lowame.
Sawdustbuildupinhopper.
Feedmotorisreversing.
Defectivethermocouple.
Defectivecontrolbox.
Firepotmorethan1/2full.
Increasefeedbyopeningfeedrateadjust-
mentcontrolrodlocatedinsidehopper.
Cleanhopper,seepage 31.
Checkforgoodconnectionsbetweenfeed
motorandwireharness.
Replacethermocouple.
Replacecontrolbox.
Seepage 33fordetailedinstructionsfor
“HighAshFuelContentManagement”
Appliancecallsforheat.
Calllightilluminates.
Exhaustblowerstarts.
Nofeedorigniter.
Thermocoupleisdefectiveornotproperly
pluggedin.
Defectivecontrolbox
Checkconnectionsonthermocoupleor
replaceifdefective.
Aashingyellowlightonthecontrolbox
indicatesaproblemwiththethermocouple.
Replacecontrolbox.