A SERVICE OF

logo

Open as PDF
next previous
R
December 16, 2011
7014-179D
Page35
CB 1200 Pellet Stove
H. Glass Replacement
• Glassis5mmthickhightemperatureheat-
resistantceramicglass.
• DONOTREPLACEwithanyothermaterial.
• Alternatematerialmayshatterandcause
injury.
WARNING
Figure 35.1
Top & Bottom Frame
Door Latch
Side
Frame
Center Posts
Glass
Remove Door Latch First
and then Side Frame
Door Frame
shown with no
Glass or Glass
Frames
Remove 5 nuts from Bottom Frame
Figure 35.2
Handleglasswithcare.
• Inspectthegaskettoensureitis
undamaged.
• DoNOTstrike,slamorscratchglass.
• DoNOToperateappliancewithglass
assemblyremoved.
WARNING
• DoNOToperatewithglasscracked,brokenorscratched.
• Removedoorfromapplianceandplacefacedown
onaprotectedsurfacetoavoidscratchingthedoor.
• Removealldoorrope.
1. Replacing Center Glass
NOTE: DO NOT LET Air Wash Spacers fall down from
top frame when removing and replacing center
glass.
a. Besuretheapplianceisallowedtocool,hasbeen
unpluggedandtheexhaustblowerisoff.
b.Using anutdriverremovethe(5)bottomnutsand
removethebottomglassframe.Figure 35.2.
c. Slightlybendupandoutofthewaythe2centerposts
andslidetheglassoutthebottom.
d.Slidenewglassin,repositionthe2centerpostsand
re-installbottomglassframe.
e.Re-ropethedoor.
2. Replacing Side Glass
NOTE: When removing the side glass with the door
latch, you must remove the door latch rst
before removing the side frame. Use a pow-
ered Phillips head screw driver to remove the
4 screws.
 a. Besuretheapplianceisallowedtocool,hasbeen
unpluggedandtheexhaustblowerisoff.
b.Removesideglassframe.
c. Loosenthetopandbottomframeandslightlybend
upandoutoftheway.
d.Slideglassoutthesideandslidenewglassin.
e.Re-installthesideglassframeandtightenthetop
andbottomframes.
f. Re-installthedoorlatch,ifapplicable,andre-rope
thedoor.